Pages 94–108 (15 pages)

Cool Pack: Description and Operation

From the 1959 Pontiac Heating, Ventilation and Air Conditioning Manual

How the Cool Pack conditioner works. It recirculates inside air through an under-dash cooling unit and leaves the luggage compartment clear. The section covers the four outlets, blower and temperature control levers, settings for fast cool-down and city driving, the compressor, condenser, receiver, expansion valve, evaporator, thermostat switch, refrigeration circuit and electrical system.

Read this section free, starting at page 94

What this section covers

  • Outlets and controls
  • Operating instructions
  • Compressor and condenser
  • Thermostatic expansion valve
  • Evaporator
  • Temperature control switch (thermostat)
  • Refrigeration circuit
  • Electrical system
Year
1959
Make
Pontiac
Vehicle
Components and Systems, Heating and Air Conditioning, Passenger Cars
Type
Service Manual
Models
1959 Pontiac: heater, ventilation, Circ-L-Aire and Cool Pack air conditioning
Pages
141

What’s inside

Heater and ventilation

  1. Heatingpp. 2–16
  2. Heater Testing and DiagnosisAn operational test for the heater with preliminary engine compartment and interior checks, followed by a complaint and remedy table for insufficient heating, poor defrosting and vacuum system faults.pp. 17–19
  3. Heater SpecificationsHeater blower switch current and rpm figures for Lo, Hi and De-Ice, cooling system capacity with and without heater, and fuse ratings.pp. 20–20
  4. VentilationHow outside air enters the cowl chamber and side shroud ventilators, with adjustment of the shroud side duct vent control cable and replacement of the top ventilator grille, its sealing strip, and the side duct outlet and door.pp. 21–23

Basic air conditioning

  1. Principles of RefrigerationThe physics behind automotive air conditioning, the five parts of a simple refrigeration system (compressor, condenser, receiver, expansion valve and evaporator), and a Freon-12 pressure-temperature table.pp. 24–25
  2. General Information on Refrigeration Servicepp. 26–30

Circ-L-Aire conditioning

  1. Circ-L-Aire: Description and Operationpp. 31–58
  2. Circ-L-Aire: Inspection and Periodic Servicepp. 59–62
  3. Circ-L-Aire: Mechanical Repairspp. 63–66
  4. Circ-L-Aire: Refrigeration Repairspp. 67–82
  5. Circ-L-Aire: Testing and Diagnosispp. 83–91
  6. Circ-L-Aire: SpecificationsBlower switch current and rpm table, Frigidaire compressor data, belt size and tension, clearances, Freon capacity, generator and regulator figures, and torque values for the Circ-L-Aire system.pp. 92–93

Cool Pack conditioning

  1. Cool Pack: Description and Operationpp. 94–108
  2. Cool Pack: Inspection and Periodic ServiceNew car pre-delivery inspection, 2,000 mile inspection, periodic service and on-car adjustments for the Cool Pack conditioner.pp. 109–111
  3. Cool Pack: Mechanical RepairsReplacement of the master relay, blower switch, temperature control switch, blower assembly and air outlets, and removing the compressor to service the engine.pp. 112–113
  4. Cool Pack: Refrigeration Repairspp. 114–128
  5. Cool Pack: Testing and Diagnosispp. 129–137
  6. Cool Pack: SpecificationsBlower switch current and rpm table, Frigidaire compressor data, belt tension, clearances, Freon capacity of 3.5 lbs., fuse ratings and torque values for Cool Pack.pp. 138–139

Index

  1. IndexAlphabetical index of subjects in the manual, with page numbers for heating, ventilation and both air conditioning systems.pp. 140–141

Other manuals for this vehicle